Ducks and Geese Part 5

_Cooling the Eggs._ There is a considerable difference in the practice of incubator operators with regard to cooling. No cooling should be done until after the first test. After this some incubator men cool the eggs by dropping the doors of the machine. Others take the trays of eggs out and put them on top of the machine. Cooling is usually done once a day.

The amount of cooling which the eggs require seems to vary greatly and here again the judgment of the operator comes into play. About the best general rule which can be given is that the eggs should be cooled until they do not feel warm to the face but they should never be cooled to the extent that they feel cold to the face or hands. The length of time to bring this about varies with the age of the eggs and the temperature of the room.

_Moisture._ A good deal of moisture is used in incubating duck eggs. It is usual to begin to spray the eggs with water the next day after testing. However, this may vary anywhere from the sixth to the tenth day. They are sprayed quite thoroughly, some men using water enough so that it runs out of the bottom of the machine. No particular care is taken to see that the water used is warm. Ordinary water just as it comes from the pipes is commonly used and is applied by means of a spray nozzle attached to a hose. However, extremely cold water should not be used for this purpose. This spraying is done once or twice a day as the operator may think necessary until the eggs begin to hatch. In many cases even then if the ducklings seem to be drying too fast after they come out of the sh.e.l.l, or to be having difficulty to get out it is well to open the machines and wet the eggs down thoroughly.

_Fertility._ The fertility varies with the season that is, with the weather. At the beginning of the laying season when the weather is cold the fertility usually runs rather low. This is likewise true at the end of the laying season when the heat of summer sets in. During the interval between these two times of low fertility there will usually be one or more periods during which the fertility will go down and then come back again. This seems to occur even though the weather remains about the same and though there is no change in the method of feeding.

Fertility may be considered to be good when it runs about 85%. When the fertility is running poor the hatching of the eggs left in the machines after testing will usually be poor also.

_Hatching._ It takes longer as a rule from the time that the ducklings pip the eggs until they hatch than it does with chicks. To retain the moisture which is so necessary during hatching, the machines are usually shut tightly and are not opened until the hatching is pretty well completed unless it becomes necessary to add more moisture as indicated above. The little ducklings should be left in the incubator until the hatching is over and they are thoroughly dried off. As soon as the hatching is completed, the ventilators in the machines are opened to hasten the drying process. If the ducklings open their bills and pant it is an indication that they are not getting enough ventilation and this should be supplied by fastening the machine door open a little way.

If the ducks are not ready to be taken out of the machines by noon or soon after, it is best to leave them until the next morning before removing them to the brooder house. In the meantime, however, the old eggs and sh.e.l.ls and other refuse should be taken out. Usually the hatch is completed in time so that the ducklings can be removed to the brooder house on the afternoon of the 28th day. As a rule the earlier the hatch is completed the better are the ducklings.

Figures secured on results in hatching for the entire season on Long Island duck farms indicate that as a whole the duck raisers will not average much over 40% hatch of all eggs set. Some hatches may run as high as 60% or even more and in some seasons the average percentage will run higher than 40. Some especially skilled operators may also secure considerably better average results than this. It is quite a common practice on the part of duck farmers to pay their incubator man a bonus on all ducklings over 40% hatched during the season. This bonus may range anywhere from $1 to $5 per thousand ducklings. Such an arrangement serves to give the incubator man a greater incentive to give the machines good attention and to secure just the best results of which he is capable.

_Selling Baby Ducks._ Within the last two or three years there has sprung into existence a small but increasing trade in baby ducks. They are handled and s.h.i.+pped about the same as baby chicks. Baby ducks are ready for s.h.i.+pment as soon as they are thoroughly dry, usually about 12 hours after the hatch starts to come off. They are neither fed nor watered before s.h.i.+pment and are packed in cardboard boxes used in s.h.i.+pping baby chicks. As a rule the s.h.i.+pping boxes will accommodate about half the number of ducklings that they will chicks. Of course the outside temperature very largely governs the matter of the number to a compartment. In warm summer weather, a two compartment box intended for 50 chicks will accommodate 26 ducklings if well ventilated at the sides and top. They are s.h.i.+pped by parcel post and can be sent anywhere within a radius of one thousand miles if the trip does not require more than 36 hours. For best results the ducklings should not be allowed to go much beyond this length of time before they are fed. On receipt they should be placed immediately in a brooder already prepared for them.

CHAPTER VI

Commercial Duck Farming--Brooding and Rearing the Young Stock

Young ducks are easier to brood than chicks. They seem to learn more quickly where the source of heat is and they are less likely to cause trouble from crowding. They are also less subject to disease.

_Removing the Newly Hatched Ducklings to the Brooder House._ The ducklings should be left in the incubator until they are thoroughly dried off. Usually they will be dried so that they can be moved on the afternoon of the 28th day of incubation. If, however, they are not ready early in the afternoon it is best to leave them in the machine until the next morning. In moving the ducklings, place them in boxes, baskets or other suitable carriers and cover them with burlap or cloth to avoid any danger of the ducklings becoming chilled.

_Brooder Houses Repaired._ There are many different types and styles of brooder houses which are used with success. For this reason only one type of each cla.s.s of brooder house needed is described in detail. These particular houses have been in successful use for a considerable period of time and are given because they embody all the necessary requisites for such houses and at the same time utilize the s.p.a.ce to good advantage and are economical in construction.

In general there are required three different brooder houses. The first of these requires sufficient heating capacity so that the temperature of the house itself can be maintained at 65 to 70 degrees even in the cold weather of winter or early spring. In addition, hovers are required in this house under which a temperature can be maintained from 80 to 90 degrees. For convenience this house will be spoken of as brooder house No. 1. A second brooder house which can be called brooder house No. 2 will be required which is equipped with heating apparatus so that the temperature can be run up to 60 degrees when required. The third brooder house known as brooder house No. 3 is a cold brooder house or one without artificial heat. It furnishes shelter for the young ducks where they can be driven in at night and during the day in cold weather. As the ducklings pa.s.s out of the brooder house No. 3 they are housed in sheds or shelters with yards which usually extend into the water but which may not do so in all cases.

Brooder House No. 1

The length of this house determines its capacity, the required amount of which will depend upon the output of any particular plant. There should be brooder capacity in this house sufficient to care for approximately of the total output for the year at one time.

_Construction of House._ A suitable house which has been in practical use for some time consists of one 20 feet wide and running east and west with windows in the south or front side. If the location were right such a house could be run north and south to good advantage and should then have windows on each side so as to let in the sunlight from both directions. The front wall of this house is 7 feet high, the back wall 4 feet. The ridge of the house is about 2 feet in front of the center, the front slope of the roof having an eight inch pitch while the back slope has a 6 inch pitch. The roof rafters are 2 4's placed every two feet.

The studs and plates are likewise 2 4. The walls are made of matched material. The roof is constructed of 1 2 inch strips placed every 4 inches and these covered with s.h.i.+ngles. Tie beams every 8 feet extend from front to rear plates. This particular brooder house is not ceiled but a good tight ceiling 8 feet above the walk or runway would make it easier to keep the house clean and would also render it somewhat easier in cold weather to maintain the temperature desired. The house is built on a concrete wall or foundation and a dirt floor is used but the dirt must be filled in well above the level of the ground outside so that there is no danger of water coming into the house or the floors becoming damp or sloppy. Windows are placed in the front wall, one to each pen.

In every other pen there is a small door in the back of the house to facilitate cleaning out the pens. A window can be subst.i.tuted for this door to good advantage as it makes the house lighter.

[Ill.u.s.tration: FIG. 23. Interior of No. 1 brooder house showing walk and hover combined in the middle of the house and pens on each side.

(_Photograph from the Bureau of Animal Industry, U. S. Department of Agriculture._)]

_Heating Apparatus._ Heat is furnished by means of a coal burning stove which heats water and causes it to circulate through pipes run the length of the house. The heater must always be placed in the windward end of the building as otherwise it is hard to get the heat down to the other end as the wind tends to drive it back. The hot water pipes are carried down the center of the house and the return pipes are located in the same place. A low part.i.tion is run lengthwise of the house dividing the pipes and thus forming double pens, half extending from the center to the front and half from the center to the rear of the house. The pipes and the part.i.tion between them is covered over with boards making a 4 foot walk or runway directly over the pipes, which comes into most convenient use as a place to convey, by means of a wheelbarrow, feed or other material needed in the house, and as a convenient place from which to care for the ducklings in the pens on each side. This board covering over the pipes also serves to hold the heat and thus forms hovers.

It is advisable to part.i.tion off the first third of the house, that is, the portion in which the heater is located, with a solid part.i.tion. Then by having suitable valves in the pipes, the heat can be cut off from the rest of the house and only the smaller part.i.tioned off end used as a separate and independent section of the brooder. This is especially useful when only a small number of ducklings are being hatched early in the spring when the weather is cold and it may be difficult to heat the whole building properly. It is also economical in fuel under such conditions.

If, on the other hand, the number of ducklings hatched during the cold weather is so large that all or nearly all of the house capacity is needed to care for them, it will usually pay to install an additional heater, the pipes from which can be run along the rear wall of the building, in order to keep up a proper house temperature when the weather is severe.

_Pens._ Having the hovers in the center of the house, makes it possible to have double sets of pens, one running from the center to the front wall and the other from the center to the rear wall. The pens are divided off by means of part.i.tions made of one foot boards. These are high enough to confine the ducklings to their own pen and at the same time are easy to step over. In a house of this width, 20 feet, with 4 feet in the center taken up by the double hovers or walk, each pen is 8 feet long in the clear or 10 feet to the part.i.tion under the hover. The pens in the first third of the house are made 5 feet wide, in the next third 6 feet and in the last third 7 feet wide. When the ducklings are first brought from the incubator cellar they are placed in the pens nearest the heater as the temperature will run somewhat higher there than in the portions of the house more remote from the heater. These 5 10 foot pens will accommodate 125 baby ducklings although better results will be obtained by placing only 100 in a pen if sufficient room is available. Some duck growers use boards which can be slipped into slots made of cleats nailed to the pen part.i.tions at different distances from the hover and which serve to confine the baby ducklings close to the hover for the first few days or until they learn to go under the hover to get warm.

As additional ducklings are hatched later and brought to the brooder house, the ducklings already there are moved along the necessary number of pens in order to accommodate the new-comers in the pens nearest the heater. For this purpose, a small door is made in each part.i.tion next the outside wall of the house through which the ducklings can be driven.

A broom is a handy implement to use in driving the ducklings as they can be pushed along in front of it. It is best to drive the ducklings just after they have been fed as they are not so nervous and afraid at that time.

The increased width of the pens in the second and third portions of the house is for the purpose of taking care of the growth of the ducklings as they are moved along the house. Pens of the same width as those in which they were started become too crowded as the ducklings increase in size.

_Equipment of the Pen._ The equipment of the pens is quite simple. Water is piped through the house along both walls so that it is available to each pen. A spigot is provided in each pen and under this is placed the drinking dish, which consists of a round metal pan about a foot in diameter and 3 or 4 inches deep. A square pan should never be used as the ducklings are apt to get their bills caught in the corners. One quarter inch mesh wire netting is bent in a circle and placed in the drinking dish as a guard to keep the ducklings from getting into the pan. This guard should be made of such size that there is a s.p.a.ce between the wire and the edge of the dish of about 1 inches all around.

This guard should be about 8 inches high. The water pan itself is set upon a wire covered frame about 18 inches square under which is dug a pit 4 or 5 inches deep to drain away any water which the ducklings slop out of the pan. Such an arrangement keeps the pens from becoming sloppy and damp.

Each pen must also have a flat metal dish on which to place the feed for the little ducks. Metal pans are better than wooden feeding trays as they are easier to keep clean.

In each pen is provided a small hopper filled with fine sharp creek sand to which the ducklings have access at all times. Some duck growers prefer to mix the sand in the feed rather than to provide it in hoppers.

After the ducklings are allowed to run in the yards, sand need not be furnished if the yards are sand as the ducklings will help themselves. If the land in the yards is not sand, however, it is necessary to continue to furnish this material.

[Ill.u.s.tration: FIG. 24. Watering arrangement in the brooder pens for young ducklings. (_Photograph from the Bureau of Animal Industry, U. S.

Department of Agriculture._)]

[Ill.u.s.tration: FIG. 25. Another type of No. 1 brooder house. Here the hovers are along the back of the house and the work is done from an alleyway along the front. The box with handles on top of the hover is used in carrying the newly hatched ducklings from the incubator cellar to the brooder house. (_Photograph from the Bureau of Animal Industry, U. S. Department of Agriculture._)]

_Grading and Sorting the Ducklings._ As the ducklings are moved from pen to pen through this house as well as the other houses, they are constantly graded for size and thriftiness, the smaller, less thrifty individuals being left with younger lots. Some ducklings do not grow as quickly as others, and these if left with ducklings larger than themselves will not get their share of the feed and will not do as well.

In this connection it should be noted that when young ducks are not fairly clean it is a good indication that they are not doing as well as they should.

_Cleaning and Bedding the Pens._ Careful attention must be given to keeping the pens and the ducklings themselves clean if they are to do well. Therefore the pens must be cleaned out as often as may be necessary to accomplish this purpose. The judgment of the brooder man must decide how often this is necessary but it will be at least once a week. When cleaning the pens the old bedding is thrown out from the front pens through the windows and from the back pens through the door provided in the rear wall for this purpose. Bedding the pens must be done more frequently, usually about every other day. Fresh bedding will help to absorb the droppings and will keep the pens from becoming sloppy or sticky. For bedding, straw, meadow hay, swale hay or any other suitable material available should be utilized.

_Ventilation._ Plenty of ventilation is required in the brooder house in order to take out the ammonia odor which arises from the droppings.

Properly managed, the doors and windows provide sufficient means of ventilation but some duck growers prefer to have roof ventilators in addition.

_Other Types of Brooder Houses._ Many other types of brooder houses are used, some of them being shed roof construction and many of them being built narrower than this house, that is to say, 14, 16 or 18 feet wide with an alleyway along the front or rear side of the house from which the work is done. The hovers are placed at the back of the pens when the alley-way is in the front, otherwise, they are placed next to the alley-way. The disadvantages of these houses are that only single pens are provided and that valuable brooding s.p.a.ce is used up by the alley-way. The advantages of the house described above lie in the fact that the hovers are in the center of the house with the pens on each side of this, thus doubling the capacity, and that by making use of a walk over the hover pipe no room is wasted in an alley-way. Having pens on each side also lessens the labor of taking care of the ducklings to some extent as the arrangement is more compact.

Length of Time in Brooder

_In House No. 1._ As a rule the ducklings are kept in the No. 1 house until they are from 2 to 3 weeks old, this of course depending somewhat upon the time of year and the weather and also upon the number of ducklings for which accommodations must be provided at any particular time. As the ducks are moved down through the house and eventually reach the last pens they are taken from this house and placed in brooder house No. 2.

_Brooder House No. 2._ This is a heated house like brooder house No. 1 but in which it is not necessary to maintain so high a temperature.

Sufficient heating apparatus should be installed to make it possible to maintain the temperature at 60 degrees if this becomes necessary in the early spring.

The particular brooder house described is 14 feet wide and has a shed roof. It is provided with a window in the front of each pen. No openings are required along the back since this is not a double pen house. The s.p.a.ce in such a house could undoubtedly be used to better advantage if it were constructed as wide as the No. 1 house and the hot water pipes and walk put through the middle of the house so as to provide double pens. In this house the hot water pipes are run along the rear of the pens, and while hovers are not really necessary, a walk is constructed over the pipes in order to save s.p.a.ce and provide a convenient place from which to do the work, and this forms hovers.

Ordinarily after May 1 no heat is needed in the No. 2 house. The pens in this house are 12 feet wide and they are equipped with feeding and watering arrangements as in brooder house No. 1. As the ducklings are moved to this house from the No. 1 house from 150 to 200 are placed in each pen. They are moved through the house from pen to pen in the same manner as in the No. 1 house to make way for new arrivals. As a rule they stay in this house about two weeks depending somewhat on the weather and upon the number of ducklings being brooded. Yards are used in connection with this house which are the same width as the pens and 50 feet in length. As in the No. 1 house the pens in this house should be cleaned at least once a week and they should be bedded with straw or other bedding material every other day. As soon as the ducks have been moved through this No. 2 house they are put in brooder house No. 3.

[Ill.u.s.tration: FIG. 26. Brooder house No. 2 and yards. The trees furnish fine shade for the growing ducklings. (_Photograph from the Bureau of Animal Industry, U. S. Department of Agriculture._)]

Brooder House No. 3

This is a shed roof house 16 feet wide equipped with single pens. No heat is required in this house. Yards of the same width as the pens and 50 feet deep are used. Usually the ducks are fed outside the house from a wagon driven along a roadway just in front of the yards.

The pens are 16 feet wide and the same number of ducks is used in them as in the No. 2 house. As a rule the ducks stay in this house about 2 weeks and are then moved to the duck pens or shelters with the larger yards which may or may not have water. From this point on the ducks are termed yard ducks.