Every Step in Canning Part 16

CANNED FISH IN TOMATO SAUCE

Handle same as specified under "Another Formula for Miscellaneous Fish," except pour in the following sauce instead of pepper, cloves, onions, etc.: Ten gallons of tomato pulp (mashed tomatoes and juice with cores, seeds and skins removed); 1 gallon cider vinegar, 1 pint Worcesters.h.i.+re sauce; 2 pounds red sweet peppers; 2 pounds sugar, 2 cups salt, 2 pounds onions (chopped fine); 1 pound West India peppers and 1 ounce Saigon cinnamon. The fish are processed same as "Fish in Oil." Enamel lined cans or gla.s.s jars must be used.

FISH CHOWDER

The cleaned heads of any fish, the backbones cut out of large fish with what meat adheres to them and all other fish sc.r.a.ps may be used for fish chowder. Put all these parts in cold water (to cover) and cook until all the meat can be easily removed from the bones. Pick all the meat from the bones, strain the fish liquor and return it with the picked fish meat to the kettle. Add the following ingredients: To every two pounds of fish picked from bones and the liquor in which fish was cooked add 6 onions, diced or sliced thin; 6 potatoes, diced or sliced thin; 2 tablespoonfuls fat; 1 teaspoonful paprika; 2 teaspoonfuls salt or salt to taste.

Cook vegetables, fat and seasonings until vegetables are half done.

Pack hot in cans and sterilize same as all other fish. When the chowder is opened, heat and add milk according to taste.

FISH ROE

For canning be sure to use roe of freshly caught fish and only such roe as is known to be good to eat. The roe of some fishes, such as the garfish, is not eaten.

Clean the roe by removing the shreds and strings adhering to it and wash well in cold water, being careful not to break the roe. Soak for 2 hours in a brine made of 6 quarts of water and 6 ounces of salt.

Drain and pack in hot gla.s.s jars or enameled tin cans. Can for the same length of time as other fish.

OYSTERS

Be sure all oysters that are to be canned are absolutely fresh, have not "soured" and contain no spoiled oysters. Oysters are opened by hand. All oysters should be rejected that have partly open sh.e.l.ls, as this is a sign that the oyster is dead and consequently not fit to eat.

Rinse the oysters to prevent any pieces of sh.e.l.l or grit from getting into the cans. Blanch 5 minutes. Cold-dip. If the canned oysters are to be sold it is required by law to mark on each can the net weight of solids or meat exclusive of liquids.

There have been a number of standard grades of oysters recognized on the Baltimore market. They are given as follows: "Standard Oysters"

(four kinds).

No. 1 cans, containing respectively 1, 3, 4 and 5 ounces of meat, after being processed in the cans.

No. 2 cans, containing respectively 3, 6, 8 and 10 ounces of meat.

"Select" and "Extra Select" Oysters contain respectively 6 ounces and 12 ounces for No. 1 and No. 2 cans. The above are the net weights of meats only that have been drained over a strainer with a wire bottom of inch mesh. These are the only grades that have so far been recognized by the trade. An even balance scale, with one platform for graduated weights and another for articles to be weighed, is used to weigh oysters or clams. It is suggested that those who are going to can clams or oysters find out from their prospective customers just what requirements are as to weights and then make their pack meet the occasion. Under no circ.u.mstances is it advisable to make any misstatements or misbrand in any respect.

After oysters have been packed in the can, fill with boiling brine made of 5 quarts of water to lb. salt to within inch from top of can. Sterilize as other fish.

CLAMS

If clams are received in a muddy condition, it is advisable, though not necessary to wash them before opening. After opening, discard broken or discolored clams. Do not can any clams unless absolutely fresh. Blanch. Cold-dip. Weigh out the amount of solid meat, after draining, that is to go into each can. Weigh and label just as oysters are weighed and labeled.

Fill can to within inch from the top with boiling brine made of 5 gallons of water and 1 pound of salt. Sterilize.

CLAM BROTH AND CHOWDER

Place the clams, after being opened, in a kettle with enough cold water to cover. Add a few stalks of celery. Boil for 10 minutes.

Season with salt, and pepper to taste and add 1 tablespoon b.u.t.ter to every 50 or 60 large clams. Can. Clam chowder can be made according to any recipe and then canned.

SHRIMPS

Shrimps when first caught are a grayish white color. They are very delicate and spoil quickly if allowed to stand for any length of time in a warm place. There are two general methods of canning shrimp--the "dry pack" and "wet pack." Nearly all the trade now calls for "wet pack" because the other always has a rather offensive odor and the meat is never so fresh and sweet of flavor as the "wet pack." Canned shrimp is very pleasing to the taste and is preferred by many to lobster for salads and stews.

Wet Pack. Medium sizes are preferable as very large shrimps are apt to be too tough and too dry. Put the shrimps into a wire scalding basket and lower into a boiling hot salt water solution made by mixing one pound of salt to each gallon of water. Allow the shrimps to remain in this bath for about five minutes, then remove and drain thoroughly.

Peel and remove viscera (entrails). The boiling and the salt will harden the meat and make the peeling comparatively easy. Pack into enameled tin cans or gla.s.s jars. Nos. 1 and 1 cans are used almost exclusively. These sizes should contain 4 oz and 9 ounces of meat respectively. It is unsafe to put in more meat than above directed, for it might cake and become solid when processed.

Add a very mild brine to within inch from top of can. For the brine use 1 teaspoonful salt to 1 quart of boiling water. Sterilize.

Dry Pack. Handle same as above, except do not pour into the cans any brine. The fish is packed in the cans and processed as follows without the addition of any liquor.

Drying of Shrimps. After shrimps are boiled and peeled they may be dried. Spread on a drier of any kind and dry at a temperature of from 110F. to 150F. When thoroughly dry pack in dry clean gla.s.s jars or in parchment-paper lined boxes.

SALMON

Scale fish, clean and wipe dry. Do not wash. If the fish are large cut in lengths to fill the cans and in sizes to pa.s.s through can openings easily. Salmon is usually packed in No. 1 cans or in flat cans. Fill cans with fish after it has been blanched 5 minutes and cold dipped.

Sterilize as other fish.

Many salmon packers lacquer the outside of their cans to prevent rusting. This is a very advisable point. The test for unsound salmon is the nose. If the contents issue an offensive odor, it is unsound.

Freezing does not hurt canned salmon.

AMERICAN OR DOMESTIC SARDINES

The fish taught and used for packing domestic sardines belong to the herring family and are said to be of the same species as the sardines of France, Portugal and Spain. There are two methods generally used in canning sardines. First, when the fish are put in a sauce such as mustard dressing or tomato sauce, and secondly where they are packed in oil.

CANNING SARDINES IN SAUCE

The heads are cut off, the scales taken off and the fish cleaned.

Blanch 5 minutes; cold dip; drain and pack into the cans dry. Cover with sauce, either mustard or tomato.

SARDINES IN OIL

The fish are prepared in the same manner as above described but instead of blanching them, they are put in wire baskets and immersed in boiling peanut or cottonseed oil until tender. Olive oil might be used, but is rather expensive. When cooked, they are drained, packed into cans in order, and the cans filled with olive oil. It is often advisable to salt the fish while fresh and before cooking as it improves the flavor.

CRAB MEAT

Put 5 gallons of water in a large kettle. Add lb. of baking soda to it. When boiling vigorously throw the live crabs in it and boil quickly for 20 minutes. Remove crabs and wash them in cold water. Pick out all meat. Wash the meat in a brine made of 1 ounce of salt dissolved in three quarts of water. Drain and pack in enameled No. 1 flat cans. Sterilize. As soon as the time of sterilizing is up, plunge the cans immediately into cold water, otherwise crab meat discolors.

For this reason, gla.s.s jars are not so well adapted to crab meat canning as tin cans.

FLAKED CODFISH