The Pig Part 14

The land is almost certain to be well managed and the stock to receive the best possible attention with, comparatively speaking, little cost as to labour. The animals on the farm are likely to be of a higher grade and the returns from them of an increased character, than when strangers and disinterested hired labour attend and feeds them.

Another of the great advantages possessed by some of our foreign compet.i.tors is the very much better supply of feeding stuffs and their very considerably lower cost. Take the United States, for instance, the enormous supply of maize alone enables American pigmen to manufacture pork at a cost which enables the packers to land bacon, hams, and lard on the British sh.o.r.es which our home pig producers cannot approach.

Although it cannot be said that the cost of labour is less in the States than in England, yet there are some countries from which we import pork products where the labour is far more plentiful and less costly. In the future the allowance for labour will have to be on a more liberal scale than hitherto when estimating the cost of producing pork, unless the number of persons owning and occupying small holdings is greatly increased.

It has been stated that our home producers of pork and bacon will obtain a considerable advantage in the future in that the freight on the imported meats will be so much higher. It is most probable that this will increase the expense of landing bacon, etc., on our markets; on the other hand, as we import so large a proportion of the pig fattening foods, the cost of food will most likely be increased to quite the same if not to a greater extent. The only plan to reduce this extra expense will be to lessen the outlay on imported foods by paying more attention to the growth of various foods suitable for pigs, attending more carefully to our pigs and feeding them on common-sense lines. In these particulars there is room for much improvement in many piggeries.

By reducing the cost of the production of pork and by the more general adoption of the system of home curing we shall not only obtain our bacon at less cost, but we shall have a far greater amount of the finest quality of bacon and hams generally available. We imagine that the reader of the earlier portion of this book will experience little difficulty in producing fine quality pork at a minimum cost--it will then remain to cure and dry it properly.

The fattened pig should not be fed for some twenty-four hours before it is killed; after slaughter the carcase should remain hanging until it is thoroughly cooled. The manner of cutting up will depend on the custom in the particular district. In some parts of the country the pig is split down, the head, feet, and tail taken off, the leaf and kidneys and the skirt taken out, the loin and the crop with a certain proportion of the lean cut off, and in some cases the shoulder blade is drawn; after the necessary tr.i.m.m.i.n.g a Wilts.h.i.+re side remains.

In other districts the ham and the shoulder are cut off and the side is converted into a middle, a ham and a shoulder or fore-ham. The jowls are taken off the head and salted with the bacon and hams. The upper part of the head, or, as it is commonly termed, the scorf, is usually used with the feet in the manufacture of brawn, or, as it is sometimes called, pork cheese--presumably from its being cooled in a form, and then turned out on to the dish on which it is served at table.

The first operation in curing is to distribute a small quant.i.ty of salt all over the meat to be cured. If allowed to remain about forty-eight hours the blood remaining in the meat will have become dissolved, and will have exuded from the carcase. This liquid should be thrown away. A mixture in the proportion of 4 lbs. salt, 1 lb. coa.r.s.e brown sugar, 1 oz. saltpetre, 1/4 oz. bay salt, and 1/4 oz. salt prunell should be prepared, and a portion of it be applied to all parts of the meat and particularly in the pocket hole, if the shoulder blade has been drawn.

This should be continued for from twenty to thirty days, according to the thickness of the meat and the degree of saltness desired. In one or two districts of a limited area it is usual to rub the meat somewhat violently with a large pebble when applying the salt mixture, the alleged object being to rub in the salt; but for this there is not the slightest necessity as the result of the rubbing is nil, since the salt will penetrate the meat equally as well without the manipulation as with it. The princ.i.p.al point is to secure the distribution of the salt to every part of the meat so that the salt can penetrate and preserve it.

When sufficiently cured the meat should be hung up and dried. If it be desired to have it smoked this is best done at the village bakery or smoke drying house. Smoking of hams and bacon is possible on a small scale with the aid of a smoke oven such as supplied by Messrs. Douglas and Sons of Putney, but it is, as a rule, cheaper and less troublesome to send the meat to the village smoking house. It will be advisable to brand or otherwise mark each piece of cured meat sent to be smoked, as the return of the same pieces is thus a.s.sured.

Where the home curing of bacon and hams is followed, this is best carried out from the middle of October to the end of March; if it be attempted earlier or later a cold chamber is necessary.

The manufacture of salt pork is carried on all the year through as the meat is usually kept in the brine, where it will keep perfectly good for a considerable time providing it is perfectly sweet when first placed in the brine. To secure this it is advisable to have the pig killed in the evening, covered over with a cloth to prevent the flies approaching it, and hanging it in a cool place so that all the natural heat has escaped ere it is cut up and placed in the pickle pot. It may be advisable to note that the last is only possible with a small pig during the hot weather. In the mere salting of pork it is usual to use only salt and saltpetre. The use of sugar should be avoided in the summer, as its use is likely to result in fermentation in hot weather.

There are two other points in connection with bacon curing on which a change of opinion has taken place, or is taking place. These are the cause of what are called in the trade "seedy bellies," and the effect on the bacon of the female fat pig being in a state of strum when it is slaughtered. Until quite recently the first of these troubles, and it is a most serious one to the trade, was generally considered to be due to the second. It was believed by curers that the slight inflammation noticeable in the mammary glands of the female pig when she is in heat resulted in these so-called "seedy bellies" if the pig was in that condition when she was slaughtered. This belief may have been either the cause or the result, or both, of the common saying that the meat of a sow pig killed when it was in heat will not take the salt properly, and that it is therefore advisable to wait until this natural condition has pa.s.sed away before the pig is slaughtered. This contention has been one of the arguments used when the spaying of sow pigs has been advocated.

Of late years comparatively few sow pigs have been spayed, so that the unspayed fat pigs have been nearly as numerous as those male pigs which have been castrated, and as the sow pigs come in heat each three weeks, and continue so for from three to five days, a very considerable proportion of them must be in heat when they are slaughtered at the large bacon-curing factories, without any loss resulting. We may, therefore, a.s.sume that it matters little whether the pig be in heat or not when it is slaughtered unless the seedy bellies result.

On this point also the verdict is against the common belief, as Messrs.

Mackenzie and Marsh have carried out a series of investigations at Cambridge which clearly proved that seedy bellies were equally as common when the sow pigs were not in heat and when they were; but that the discoloration which resembles numbers of small spots of colour varying from dark blue to light red in the mammary glands is merely an excess of pigment, the darker shade being common in pigs with dark coloured hair and skin such as the Large Blacks, Berks.h.i.+res, etc., and the lighter shade in pigs of the Tamworth breed. In the bacon manufactured from pigs with a white skin and white hair there is no discoloration or seedy bellies.

Although it has been generally considered by bacon curers that pigs of a white colour were preferable for their trade, and this to such an extent that some of the bacon curers in Ireland will pay a slightly higher price for a pig with a white skin, the preference was generally considered to be due to the more presentable appearance of a side of bacon from a white than from a black pig; it would appear that in the future a still greater preference will be observable when it becomes generally known that the bacon made from white pigs is free from seedy bellies.

_To make money out of Pigs_

One must go on the NON-STOP PRINCIPLE, every little check to growth means so much less profit. Now we know and there are thousands of other pig feeders know that WILLSON'S CANADIAN PIG POWDERS are just the very thing that is wanted, one or two powders a week to each Pig enables them to digest their food and get the very utmost out of it. Nature does the rest. You will find this so and the cost of powders is very small.

[Ill.u.s.tration: Willson's Canadian Pig Powders]

_are a Great Investment_

[Ill.u.s.tration:

+--------------------------+ 7 for 6d., post free 7d. 16 " 1/- " 1/2 48 " 2/9 " 3/- 144 " 8/- " and in bulk in tins 21/- post free. _We have agents almost everywhere._ +--------------------------+

_Sole Manufacturer:_

STEPHEN WILLSON Canadian Pig Powder Factory PETERBOROUGH (_Who also keeps a big experimental piggery_).

Continuous Cropping and Tillage Dairy Farming for Small Farmers.

By T. WIBBERLEY, N.D.A., N.D.D.

Third Edition. Price 3/6 net; postage 4d.

Here Mr. Wibberley describes specially for the benefit of the small man his system of all-weather farming, capable of doubling or trebling the profits of even the best regulated small dairy farms. In this book he discloses for the first time the whole secret of his success and the success of the many thousands of small dairy farmers who follow him.

_Of all Booksellers or from the Publishers_, C. ARTHUR PEARSON, Ltd., HENRIETTA STREET, LONDON, W.C.2.