Economy of the Round Dairy Barn Part 3

67 " 2 6 18 "

4 " 2 6 26 "

60 " 2 6 12 "

30 " 2 6 22 "

4 " 2 6 24 "

6 " 2 8 10 "

9 " 2 8 16 "

4 " 2 10 14 "

11 " 2 10 12 "

1 " 2 10 22 "

1 " 1 10 12 "

1 " 1 10 14 Cypress 2 " 1 12 14 "

22 " 1-1/8 8 10 Cyp. S2S 2 " 1 1-1/8 12 14 "

2 " 1 1-1/8 12 16 "

6000 feet of 8-inch s.h.i.+p lap 3150 feet of 10-inch s.h.i.+p lap 71 M 5/2 red cedar s.h.i.+ngles 165 Lineal feet of 2-inch Cr. molding 240 Lineal feet of Cr. molding 270 feet of 4-inch Y. P. S1S 4000 feet of 6-inch rough pine 62 feet of 3/8-inch Y. P. Ceiling 850 feet of 6-inch No. 1 flooring 230 feet of 6-inch fence flooring 56 lineal feet of 1/2 3-inch battening 32 lineal feet of lattice 444 lineal feet of 4-inch cypress 3 10-foot cedar posts Total cost of lumber $1,313.63

Mill work: Window sash and doors $270.00 Window and door frames 71.00 Sawing lumber for silo, roof, bridge and stanchions 29.78 Cost of hardware 96.57

Carpenter work: Head carpenter 518 hrs. @ 40c = $207.20 Carpenters 1057 hrs. @ 35c = 369.95 Common labor 429 hrs. @ 20c = 85.80 ------- Total cost for carpenter work 662.95

Tiling around barn and silo, sewer from dairy room, retaining wall, cement floor in alley, dairy, doorway of barn, and steps and tanks 128.54 Plastering dairy room and inside of silo 104.60 Painting 89.54 -------- Total cost of barn $3670.61

[Ill.u.s.tration: FIG. 26. BARN NO. 2. 80 FEET IN DIAMETER; ENGINE ROOM IN FOREGROUND.]

The cost of this barn, if built on the ordinary dairy farm, could be materially reduced without shortening the life of the barn. Owing to the conditions under which this barn was built, it was necessary to pay for hauling all material to the farm, two and one-half miles from town. All of the labor had to be hired, and as it was necessary for the men to board themselves the wages paid were proportionately higher. The farmer usually does the excavating and hauls the brick, sand, and lumber with his own teams, tends the mason, and does quite an amount of the rough work with his own help, besides boarding the men, all of which would greatly reduce the cost. The construction could also be cheapened by using drop siding to cover the outside, instead of s.h.i.+ngles, which in this case were used over s.h.i.+p lap on the side walls to improve the appearance. This barn could be still further cheapened by putting hoops, five feet apart, around the studs, and covering with common 1 12 boards, put on vertically, as is done in some cases. A saving could also be made on the mill work and large doors by having the carpenters make these plainer and leave the windows out of them.

Anyone wis.h.i.+ng to build a round barn can get local bids on the lumber bill, and determine approximately the cost in his locality. This will vary with both the location and the year.

OTHER ROUND DAIRY BARNS

BARN NO. 2

Built 1897.

Diameter, 80 feet.

Capacity, 75 cows in 2 rows, tails together, 51 head in outer circle, 24 head in inner circle.

[Ill.u.s.tration: FIG. 27. INTERIOR OF BARN NO. 2. SHOWING TWO ROWS OF STANCHIONS AND DRIVE BEHIND COWS WHICH IS USED IN CLEANING BARN; SILO ON RIGHT.]

Cost, $1800.

Studs, 2 6s, placed 2-1/2 feet on center.

Supports, two 2 6s in each stanchion.

Joists, main span 3 12s, 20 feet long, placed 14 inches on center.

Short spans over feed alleys, 2 10s.

Plate, 1 10-inch boards sprung around near top of studs.

Roof supports, 6 6s placed 12 feet apart. Purline plate rests on these posts and consists of 1 8s sprung to the circle.

Siding, 8-inch, put on horizontally, first story ceiled inside.

To clean out, a wagon is driven around between the two rows of cows.

The chief objection to this barn is insufficient light in the cow stable.

This barn and No. 3 are approximately the same in construction, and are more substantially built than barns No. 4 and 5.

[Ill.u.s.tration: FIG. 28. ARRANGEMENT OF COW STABLE IN BARN NO. 2; TWO ROWS OF COWS TAILED TOGETHER. THE BARN IS CLEANED BY DRIVING AROUND BEHIND THE COWS.]

[Ill.u.s.tration: FIG. 29. BARN NO. 3. 80 FEET IN DIAMETER.]

BARN NO. 4

Built in 1900.

Diameter, 90 feet.

Capacity, 105 cows, two rows heading together.

Cost, $3000.

Foundation, width at base and top, 18 inches; depth in ground, 20 inches, (not sufficient).

Sills, 2 8s, sawed in short lengths, and placed flatwise.

Studding, 20-foot 2 8s, placed 3 feet on center and toenailed to sill.

Supports, first story 4 4s placed between stanchions in each row, making two rows of supports between the outside wall and the silo; 4 4s cut to a circle placed on top of these supports. The outside span, over cows, is 13 feet 6 inches; middle span, over feed alley, 6 feet 8 inches, and inside span, over cows, 13 feet.

Joists, 2 8s placed 3 feet apart at studs on outside wall. There are as many joists in center of barn as at the outside.

Supports, second-story, consist of one row of posts running around at a point immediately under the break in the roof. These are 16 feet apart and are made of three 2 8s kept 2 inches apart by horizontal braces which run from studding near the eave thru these posts to studding in silo. See Fig. 31.

Plate, rafter is set on top of each stud, and no plate is used.

Rafters, 2 6s resting on studs at outside and on circular plate at break in roof.

[Ill.u.s.tration: FIG. 30. BARN NO. 4. 90 FEET IN DIAMETER; ONE OF THE FEW DAIRY BARNS WITH SUFFICIENT LIGHT; SAME SCALE AS DRAWING ON PAGE 37.]

[Ill.u.s.tration: FIG. 31. SILO IN CENTER OF BARN NO. 4; UPPER PORTION IN HAY LOFT. LOWER PORTION IN COW STABLE.]