Through Finland in Carts Part 34

"And," he added, laughing, "we will go and fetch _filbunke_, if you like, and then you can all sit inside rings of your own."

"No," we replied, "instead of doing that, let us get away from here as quickly as possible."

Out we sallied, therefore, to ask the coachman how soon he could be ready to drive on to _Kajana_.

How typical. There was one of the lads, aged thirteen, lying on his back, flat out on the wooden steps of the house, smoking hard at a native pipe; his felt hat was pulled down over his eyes, his top boots were standing beside him, and over them hung the rags he used for stockings.

"Go on," he said. "Oh! we cannot go on till this afternoon, it's too hot."

"But," remonstrated Grandpapa, "it is not so very far to _Kajana_, and the ladies are anxious to get to the end of their journey."

"Quite impossible," he replied, "the horses must rest."

Wherein he certainly was right; the poor brutes had come well, and, after all, whatever the horrors and inconveniences may be to oneself, one cannot drive dumb animals to death, so, therefore, at that _majatalo_ we stayed, weary and hungry prisoners for hours. Only think of it!

Oh, how glad we were to shake the dust of that station from our feet, and how ridiculous it seemed to us that such dirty untidy folk could exist in the present day, to whom "Cleanliness is next to G.o.dliness" was an unknown fact.

We found some amus.e.m.e.nt, however, for the family had just received in a box-case a sewing-machine--a real English sewing-machine. A "traveller"

had been round even to this sequestered spot, possessed of sufficient eloquence to persuade the farmer to buy his goods, and it certainly did seem remarkable that in such a primitive homestead, with its spinning-wheel and hand-loom in one corner, a sewing machine and a new American clock should stand in the other.

On we jogged; but, be it owned, so many consecutive days' driving and so few hours' rest, in carts without springs or seats and without backs, were beginning to tell, and we were one and all finding our backbones getting very limp. The poor little ponies too began to show signs of fatigue, but luckily we at last reached a hilltop which showed we were drawing close to the end of our _karra_ journey. We pulled up for a while to give the poor creatures time to breathe, and for us to see the wide-spreading forests around. The view extended for miles and miles, and undulating away to the horizon, nothing appeared but pine-trees.

No one can imagine the vastness, the black darkness, the sombre grandness of those pine forests of Finland.

Then the descent began; there were terribly steep little bits, where the one idea of the ponies seemed to be to fly away from the wheels that were tearing along behind them. We held on tightly to the blue knitted reins, for the descents in some places were so severe that even those sure-footed little ponies were inclined to stumble--fatigue was the cause, no doubt;--but if our own descent were exciting, it was yet more alarming to look back at the _karra_ following, too close for comfort, behind us, literally waggling from side to side in their fast and precipitous descent, encircled by clouds of dust.

_Kajana_ at last. What a promised haven of rest after travelling for days in springless carts, happily through some of the most beautiful and interesting parts of Finland.

CHAPTER XVII

TAR-BOATS

Tar hardly sounds exciting; but the transport of tar can be thrilling.

We were worn out and weary when we reached _Kajana_, where we were the only visitors in the hotel, and, as the beds very rapidly proved impossible, we women-folk confiscated the large--and I suppose only--sitting-room as our bed-chamber. A horsehair sofa, of a hard old-fas.h.i.+oned type, formed a downy couch for one; the dining-table, covered by one of the travelling-rugs, answered as a bed--rather of the prison plank-bed order--for number two; and the old-fas.h.i.+oned spinet, standing against the wall, furnished sleeping accommodation for number three. We had some compunctions on retiring to rest, because, after our luxurious beds had been _fixed up_, as the Americans would say, we discovered there was no means whatever for fastening the door,--it was, as usual, minus bolts and locks; but as _Kajana_ was a quiet sleepy little town, and no one else was staying in the hotel but our own men-folk on the other side of the courtyard, weary and worn out with our jolty drive, and our waterfall bath, we lay down to rest. We were all half asleep when the door suddenly opened and in marched two men. They stood transfixed, for of course it was quite light enough for them to see the strange positions of the three occupants of the sitting-room; and the sight scared them even more than their appearance surprised us, for they turned and fled. We could not help laughing, and wondering what strange tales of our eccentricities would enliven the town that night.

Descending the rapids of the _Uleborg_ river in a tar-boat is one of the most exciting experiences imaginable. Ice-boat sailing in Holland, _skilobnung_ (snow-shoeing) in Norway, tobogganing in Switzerland, horse-riding in Morocco--all have their charms and their dangers--but, even to an old traveller, a tar-boat and a cataract proved new-found joys. There is a vast district in Finland, about 65 North lat.i.tude, extending from the frontier of Russia right across to _Uleborg_ on the Gulf of Bothnia where tar plays a very important role; so important, in fact, that this large stretch of land, as big or bigger than Wales, is practically given over to its manufacture and transport.

After leaving _Kuopio_, as we had travelled Northwards towards Lapland, the aspect of the country altered every twenty miles. It became far more hilly, for Finland, as a whole, is flat. The vegetation had changed likewise, and we suddenly found ourselves among tracts of dwarf birch so familiar to travellers in Iceland.

As we had driven on towards _Kajana_ we had repeatedly pa.s.sed pine-trees from which part of the bark was cut away, and, not realising we were now in _tar-land_, wondered at such destruction.

The history of the tar, with which we are so familiar, is very strange, and not unmixed with dangers. Pine-trees, growing in great forests where the bear, wolf, and elk are not unknown, are chosen for its production.

The first year the bark is carefully cut away from the ground as high as a man can reach, except on the northern side of the tree, where a strip two inches wide is left intact. Now this strip is always the strongest part of the bark because it faces northwards, and it is, therefore, left to keep the tree alive and to prevent it from drying. All the rest of the trunk remains bare, s.h.i.+ning white and silvery in the sunlight, and forms a thick yellow juice, which oozes out of the tree, and smells strongly of turpentine. This ultimately makes the tar.

The next year the same process is repeated, except that then the bark is peeled higher up the tree, the strip on the northern side always being left as before to keep the sap alive. The tenacity of the life of bark is wonderful, as may be seen at a place like Burnham Beeches, where, in many cases, all the inside of the tree has practically gone, and yet the bark lives and the tree produces leaves.

This treatment goes on for four, and sometimes five, years, until most of the tree is stripped. It was in this naked condition the pines first attracted our attention, for a barkless tree covered with a thick yellow sap, to the uninitiated, is an unusual sight. In October, or early in November, of each year the selected pines are duly cut down, and later, by the aid of sledges, they are dragged over the snow through the forests to the nearest _tervahauta_ (kiln), there to be burnt into tar.

So cold is it in this part of the world during winter that the thermometer often drops to 30 or 40 Fahr. below freezing-point, and then the hard-worked little horses look like b.a.l.l.s of snow, the heat from their bodies forming drops at the end of their manes, tails, and even their long coats, for their hair grows to an even greater length than the Shetland ponies. At last their coats become so stiff they are not able to move, so they often have to be taken indoors and thawed by the oven's friendly warmth.

These st.u.r.dy little beasts gallop over the hardened forest track, dragging their wood behind them--for without the aid of snow to level the roads, or ice to enable the peasants to make short cuts across the lakes, little trade could be done. The winter comes as a boon and a blessing to man in those Northern realms; all transport is performed by its aid, sledges travel over snow more easily than wheels over roadless ways, and _sukset_ or ski and snowshoes traverse snow or ice more rapidly than the ordinary summer pedestrian.

Suffocated with heat and dust, we were ourselves b.u.mping along in a springless _karra_, when our attention was first arrested by--what? let us say a huge basin built on piles. This was a _tervahauta_ or tar-kiln, which looked like an enormous mushroom turned upside down, standing on a thick stem of wooden piles, only in this case the mushroom was ninety or a hundred feet in circ.u.mference, and the stem at least fifteen feet wide.

As we have nothing at all like it in England, it is difficult to describe its appearance. Think of a flattened basin or soup-plate made of pine-trees and covered over with cement, so that an enormous fire may burn for days upon it. In the middle, which slopes downwards like a wine funnel, is a hole for the tar to run through into a wooden pipe, which carries it to the base of the kiln; pa.s.sing along to the outside, the wooden pipe is arranged in such a way that a barrel can be put at the end to receive the tar. This vast basin has to be very solidly built in order to withstand the weight of wood--sometimes over a hundred trees at a time--and also the ravages of fire, therefore it is securely fastened and supported at the edges by whole trunks of trees bound together with cement. Once built, however, it lasts for years, and, therefore, most tar-farmers have a _tervahauta_ of their own.

The felled timber, having been sawn into pieces about a yard long in order that they may be conveniently packed on the sledges, arrive at the kiln before spring, so that by June all is ready for the actual manufacture of the tar itself. The _tervahauta_ basin is then packed as full as it is possible to stack the wood, which is always laid round the middle in order to leave a hole in the centre free to receive the tar.

By the time the ma.s.s is ready it looks like a small hillock, and is made even more so in appearance by being thickly covered over with turf, that it may be quite air-tight, and that a sort of dry distillation may go on. Fires are then lighted at different points round the edge, to the end that the interior may catch fire, the process being aided by a train of old tar which runs from the burning point to the centre, as dynamite is laid prior to an explosion. By this means the whole huge bonfire shortly begins to smoulder.

The fire burns for ten days and nights, during which time it is never left, a man always staying beside the _tervahauta_ to see no accident disastrous to the tar happens. As the heat inside increases, the tar gradually begins to drop through the wooden pipe into barrels below, and from sixty to two hundred of them may be extracted from one kiln load.

Needless to say, one man cannot move the filled barrel and replace it with an empty one, so, whenever such a change becomes necessary, by means of a shrill whistle he summons a companion to his aid; at other times he sits alone and watches for hours together the smouldering flames.

Making the barrels is another Finnish trade, and the peasants, who manufacture them in winter, get from eightpence to tenpence each, for they have to be very strong. It is, indeed, much more difficult to make a tar-barrel than a water-cask.

Here ingenuity has to come to the peasant's aid; each barrel, when filled, weighs about four hundred pounds, and has to be conveyed from the forest country to the nearest waterway or town. Finns rise to the occasion, however. They take thick pieces of wood, on to which a kind of axle is securely attached, and adjusting them by means of ingenious pegs fixed at both ends of the barrel, where the side pieces of wood project beyond the actual top and bottom, the cask itself practically becomes its own wheels. Wooden shafts are fixed from the axle to the horse's collar, and though, with his queer load, the little ponies are not beauties to look at, they are marvels to go, trotting along over tree trunks and stony boulders to the nearest waterway, the barrels following--carriage and wheels in one.

After many vicissitudes this tar arrives at the end of its land journey--but if that be on the frontier of Russia, it may still have two hundred and fifty miles of river, lake, and rapid to traverse before it reaches _Uleborg_, where it is trans.h.i.+pped to England, America, and Germany.

It had been arranged that we were to descend the wonderful rapids from _Kajana_ to _Uleborg_, a day and a half's journey; but we wanted to taste something of the ascent as well,--there is no _down_ without an _up_, and we thought we should like to try both. The tar-boats that go down the _Oulunjoki_ river, heavily laden with their wares, take two or three days, and have to come up again empty; this is the heaviest and most tiring part of the whole performance to the boatmen, and cannot be accomplished under two or three weeks. They sometimes bring back five hundred or six hundred pounds of salt or flour, for although they take down twenty-five or thirty times as much as this in weight, they cannot manage more on the return journey, when, to lighten the boat as much as possible, they even take off the top planks or bulwarks and leave them behind at _Uleborg_, putting new bulwarks a foot broad made of half-inch plank before the next downward voyage.

A tar-boat is a very peculiar craft, and, when one sees it for the first time, it seems impossible that anything so fragile can travel over two hundred miles by river, rapid, lake, and cataract. The boats are generally from thirty-five to forty-five feet long, but never more than four feet wide, or they could not be steered between the rocks of the swirling cataracts. They are pointed at both ends like a gondola, but it is not the narrowness and length that strike terror into the heart of a stranger, but rather the thinness of the wood of which they are built.

The boat is made of the planks of well-grown trees, which planks, though over a foot wide, are sawn down to three-quarters of an inch thick, so that in the strongest part only three-quarters of an inch divides pa.s.sengers and crew from the water, that water being full of rocks and swirling whirlpools. Four planks a foot wide and three-quarters of an inch thick, as a rule, make the sides of a tar-boat, not nailed, be it understood, but merely _tied_ together with pieces of thin birch twig!

Holes are bored, the birch threaded through, securely fastened, and then, to make the whole thing water-tight, the seams are well caulked with tar. This simple tying process gives the craft great flexibility, and if she graze a rock, or be buffeted by an extra heavy wave, she bends instead of breaking.

From all this it will be inferred the boat is extraordinarily light, or it could never be got home again--but when twenty-four or twenty-eight barrels, each weighing four to five hundred pounds, are in it, the water comes right up to the gunwale, so an extra planking of a foot wide is tied on in the manner aforementioned, to keep the waves out, and that planking is only half an inch thick. Therefore the barrels are only divided from the seething water by three-quarters of an inch, and the waves are kept back by even a slighter barrier.

It is amazing that such a long fragile craft can survive that torrent of water at all.

When the last boats go down in October, ice has already begun to form, and they frequently suffer very much from its sharp edges, for which reason the perils of those late journeys are often hideous. When the tar-barrels reach _Kajana_ from the forests they are only worth from twelve to eighteen marks each, and if one considers the labour entailed to get them there, it seems remarkable that any profit can be made out of the trade. Very cleverly the heavy tubs are lifted by a crane into the boat, which is just wide enough to take them in twos and twos lengthwise--three or four perhaps being placed on the top of all. The biggest cargo consists of twenty-eight barrels. Before the tubs are really s.h.i.+pped they are tested, as wine is tested, to see that the quality is all right, and that they are worth the perilous carriage. So many of these boats ply backwards and forwards during July, August, September, and October, that sometimes as many as a hundred will pa.s.s _Kajana_ in one day. This gives some idea of the industry and its enormous importance to that vast tract of country. Indeed, from 50,000 to 70,000 barrels find their way down the _Uleborg_ river alone during these months.

Owing to the courtesy of _Herr Fabrikor Herman Renfors_, to whom the Governor of the Province had kindly given us an introduction, we went a mile and a half up the rapids and through a couple of locks in his private tar-boat, just for the experience. The heat being tropical, we did not start till six P.M., when we found _Herr Renfors_ waiting at the entrance to the first lock, as arranged, in a real tar-boat, which he was steering himself, for, being an enthusiastic fisherman, he goes out alone for days at a time, and can steer up or down the rapids as well as any pilot. No one who has not seen a rapid can realise the nerve this requires. Seats had been roughly put in for us to sit on, otherwise, as a rule, except for the oarsmen's bench and the barrels, these boats are absolutely empty. Our friend, the steersman, sat at the bow, and with a sort of oar, held in position by a rope of plaited straw fixed a little on one side, guided the fragile bark. First we had to go into a lock.

Any one acquainted with a nice wide shallow Thames lock may think he knows all about such matters; but in reality he does nothing of the kind. For this Finnish lock, and there are two of them close together, is very long, forty-five feet being required for the boat alone, and nearly as much for the rush of water at each end to prevent that single boat being swamped. As the rise of water is over twenty feet, the lock is some forty feet deep and only six or seven feet wide. The walls are tarred black, and, although the sun blazed outside, when we entered this long narrow vault the air struck chill and cold, and it was so dark and weird that it seemed like going into an underground cellar, or an elongated coffin. As those ma.s.sive wooden doors closed behind us, we felt as though we were about to be buried alive in a well, or were enacting some gruesome scene fitted for Dante's wondrous pen when dipped in ink of horror. The gates slammed. The chains grated. The two oarsmen steadied the boat by means of poles which they held against the sides of those dark walls, the steersman with another pole kept her off the newly shut ma.s.sive wooden door--and then--oh! we gasped, as a volume of water over ten feet descended a little in front of us, absolutely soaking the oarsmen, and showering spray over every one.

It was a wonderful sensation; we were walled in, we were deep in the lock, and as the water poured down in two falls, for there was a platform half way to break its tremendous force, our boat bobbed up and down like a c.o.c.kle-sh.e.l.l. We felt an upset meant death, for no one could possibly have climbed up those steep black walls, still less swum or even kept his head above such volumes of water.

Up, up, up, we went until we had risen over twenty feet, which dwindled to nothing when the door opened at the end of the waterfall and we glided out into the world of suns.h.i.+ne, to see our friend the old castle before us again, the pine-trees on the banks, and the funny little wooden town on our right. Verily a transformation scene--a return to life and light and air, after water and darkness.

Before us was a small rapid, and, having rowed up under the lee of the land, it was perfectly marvellous to see how the boat was suddenly turned right across the bubbling water, and steered like a gliding eel in and out of waves and spray to the other side, which we reached by means of hard pulling, without losing more than thirty or forty feet by the strong current. Here came another lock, and several minutes were again spent in rising another twenty feet, before we were at a level to continue our course. Then came a stretch which could be rowed, although, of course, the stream was always against us; but two stalwart Finns sitting side by side pulled well, and on we sped until the next rapid was reached, when out we all had to bundle, and the fragile craft had to be towed, as the strength of the water made it impossible to row against it. There was a path of rocky boulders, uneven and somewhat primitive, such a towing path being always found beside the rapids, as the oarsmen have to get out and tow at all such places. Therefore, when returning home from _Uleborg_, the sailors have to row either against the stream (one long tract, however, being across a lake where it is possible to sail), or else they have to walk and pull. No wonder it takes them three weeks to make the voyage.

Having landed us, the two oarsmen pulled with a rope, but as the boat would have been torn to pieces on the rocks beside the bubbling water, the steersman had to keep her off by means of a long pole; and hard work he evidently found it, bending the whole weight of his body in the process, straining every nerve at times. It is terrific exertion to get even such a light thing as a tar-boat over such places, and in a mile and a half we had to get out four times as well as pa.s.s through the two locks (there are but four on the whole river), and we only reached the pilot station after working a whole hour and a half, which gave us a good idea of the weariness of toiling up stream, and the wonders of coming down, for we retraced the same route in exactly fourteen minutes.

We crossed the famous rapid, described in _Kalevala_ as the scene where one of the heroes went swirling round and round; we watched women steering with marvellous agility and skill, and there, on the bank, we saw a stalwart Finn, with an artistic pink s.h.i.+rt, awaiting our arrival to pilot us down again, our host preferring to employ a pilot for the descent when he had any one on board besides himself.

The pilot was a splendidly made young fellow of twenty-four; a very picture, with his tan trousers, and long brown leather boots doubled back under the knee like a brigand, but ready to pull up to the thigh when necessary. On his felt cap he wore a silver badge with the letters L.M. clearly stamped. "What do they mean?" we asked.